Weird charging issue *Alt and Battery good*
05-04-2018, 05:17 PM
#1
Supreme Member
Thread Starter
iTrader: (7)
Join Date: Nov 2006
Location: Alamogordo, NM
Posts: 3,740
Likes: 0
Received 9 Likes
on
9 Posts
Car: 88 Formula 350
Engine: 5.7
Transmission: T-56
Axle/Gears: 9" 3.89
Weird charging issue *Alt and Battery good*
When it's cold out I noticed the car battery won't charge. Volt gauge will sit about 8 and slowly progress down. The lower the battery gets the worse the car runs almost like the alternator isn't doing anything. Will begin to hesitate and want to stall. When the weather warms up, the car starts up and runs great, voltage on gauge goes to 13 and all is well in the world. I had the alternator checked 3 times, and I have swapped in two different batteries. Grounds seem to be fine. Has anyone had this issue and pin pointed the problem? It's very odd and hard to tell if the car is going to run good or not. It's an 87 Trans Am 5.7.
05-04-2018, 05:54 PM
#3
Supreme Member
iTrader: (1)
Join Date: Feb 2017
Location: Meriden, CT 06450
Posts: 4,034
Received 517 Likes
on
431 Posts
Car: 84 TA orig. 305 LG4 "H" E4ME
Engine: 334 SBC - stroked 305 M4ME Q-Jet
Transmission: upgraded 700R4 3200 stall
Axle/Gears: 10bolt 4.10 Posi w Lakewood TA Bars
Re: Weird charging issue *Alt and Battery good*
Make sure the connections at the connector on the side of the alternator case are good.
I had loose connections there drive me crazy for a while.
If they are not tight, replace the pigtail there.
I had loose connections there drive me crazy for a while.
If they are not tight, replace the pigtail there.
05-04-2018, 07:42 PM
#4
Re: Weird charging issue *Alt and Battery good*
You may need to change out and upgrade your alternator wire. Gm thought it was a good idea to put a #8 or #10 wire between the alt. and battery. #6 should be used, because even if a strand or two is broke, that's like trying to push a fire hose full of water wide open through a garden hose. You can also do a voltage check on that wire to check for voltage drop.
05-04-2018, 08:41 PM
#5
Supreme Member
Thread Starter
iTrader: (7)
Join Date: Nov 2006
Location: Alamogordo, NM
Posts: 3,740
Likes: 0
Received 9 Likes
on
9 Posts
Car: 88 Formula 350
Engine: 5.7
Transmission: T-56
Axle/Gears: 9" 3.89
Re: Weird charging issue *Alt and Battery good*
You may need to change out and upgrade your alternator wire. Gm thought it was a good idea to put a #8 or #10 wire between the alt. and battery. #6 should be used, because even if a strand or two is broke, that's like trying to push a fire hose full of water wide open through a garden hose. You can also do a voltage check on that wire to check for voltage drop.
05-05-2018, 07:08 AM
#7
Moderator
iTrader: (1)
Join Date: Mar 2002
Location: Chasing Electrons
Posts: 18,405
Likes: 0
Received 216 Likes
on
202 Posts
Car: check
Engine: check
Transmission: check
Re: Weird charging issue *Alt and Battery good*
When the alternator was tested, was it cold such as when it fails? May want to put it into the freezer for a few hours then place it in an ice chest to take it to be tested.
Also, next time it fails on the car measure the alternator voltage at the BAT stud. Should be the normal output voltage. If it is then the alternator is OK and there is a wiring issue.
RBob.
Also, next time it fails on the car measure the alternator voltage at the BAT stud. Should be the normal output voltage. If it is then the alternator is OK and there is a wiring issue.
RBob.
Thread
Thread Starter
Forum
Replies
Last Post
ThatTransAmGuy
Electronics
1
08-06-2011 11:10 PM
IfknROC85
Tech / General Engine
4
05-25-2010 11:04 AM